Ford Automobiles Forum banner
injectors
1-20 of 61 Results
  1. Diesel Engines (Mondeo Mk3)
    Hi guys!! I've recently removed all my injectors, had them ultrasonically cleaned, new seals and pipes refitted in a different order and reprogramed. when running normally this has had a wonderful effect, the engine is quieter and smoother, ignoring the problem I am having with the aux belt...
  2. Diesel Engines (Mondeo Mk3)
    Hello guys, it's me again... So, I bought new injectors and... everything is fine, except... When at low revs (idle) (1500-1800rpm) and slowly pulling away or manouvering, the engine sounds very clattery for a few seconds - is this normal? as the accelerator is depressed and the revs increase...
  3. Serious Power/Performance/Mapping/Rolling Roads
    Hello guys, I was read that the maximum output power from the stock injectors is approximately 250hp in STDrivers forum, is that true? I have configuration in my mind for my Mondeo 2.2TDCI as follows: - FMIC - Hybrid Turbo...
  4. Diesel Engines (Mondeo Mk3)
    Today i got three injectors from a Jaguar that was towed to the scrap yard. I took a punt with them at £10 each and installed them to my 2.0 TDCI 130. After programming them to the car and bleeding the fuel lines the car would not turn over and throw P2291 injector control pressure too low...
  5. Diesel Engines (Mk4 Mondeo)
    Hi there again, I am here to obtain as many answers to my problems, so if it is possible, i hope for responses asap :) My mondeo MK4 2.0 tdci Ghia 103 kw 6-gear sedan is starting roughly in lower temperatures. When it's over 20degrees celcium it starts with no problems in one to two turns...
  6. Diesel Engines (Mondeo Mk3)
    Hi All Reassurance needed. I recently had the glow plug light come on under heavy acceleration. I took the car for diagnostics and was told that it was fuel pump issue. They were unable to do the job but recommended someone who could. It turned out that I needed four new injectors not recons...
  7. Diesel Engines (Mondeo Mk3)
    Hi, I have looked for similar threads but can't seem to find anything specific to my issue. I currently have an intermittent fault with my Mk3 ST TDCI, primarily during cold weather. Struggles to start (3-4 attempts) then when it does fire up, immediately cuts out. This can cut out 3-4 times...
  8. Diesel Engines (Mondeo Mk3)
    Hi all I've been struggling with my MK3 Mondeo TDCI 2,0 130 hp (FMBA). I've read about it for hours. Problem: Car does not start. I have a Bosch tester at my disposal, and I can follow the values just fine. When cranking it will give me 200 or 300 bars of pressure, but that pressure drops off...
  9. Diesel Engines (Mondeo Mk3)
    Hi guys, Hopefully I'm just being paranoid... I only see white smoke under acceleration at night in cars lights behind me. The rest of the time it doesn't smoke, idles fine and pulls like a train. Should I be worrying about anything or is this normal? Cheers Dunk
  10. Diesel Engines (Mondeo Mk3)
    Hi not sure if im posting this in the right place but i could really do with some heelp from the experts. Basically my 54 plate 2.0 130ps mondeo shit itself the other day and im now in need of a new engine. I have found one of the older 130 ps duratorq engines (2001-2003), which as far as I...
  11. Diesel Engines (Mondeo Mk3)
    Hi, I have a Mondeo 2.0 TDCI 130 2007 euro 4, recently it has started cutting out with fault codes P2051 and P1211. I changed the filter (genuine delphi) but this made no difference. Opened the old filter which was completely clean with no metallic particles so fairly confident the pump is...
  12. Diesel Engines (Mk4 Mondeo)
    Hi, I have got a problem with my Mondeo '08. I was installing the HIDs (I know what you think at least I have got a projector lamps) and I have put the polarity wrong way around it. Obviously light didn't come up so I have changed the polarity to the correct one and it was fine. Light came up...
  13. Diesel Engines (Mk4 Mondeo)
    Hi All, I am facing an odd issue with my Ford Mondeo. I have had the engine malfunction light on recently and vehicle went into limp mode afterwards but the local diesel specialist is unable to identify the problem. Now I am looking for a way out. The sequence of events is as following - 1)...
  14. Diesel Engines (Mondeo Mk3)
    Hi all, I need help!!! I have a 2006 MK3 TDCi Mondeo, with 120K miles on the clock. Bought the car 3 years ago and have run into a number of issues lately, the latest being last night when the back box came off my car and ripped off the mud flap and rear bumper in the process. I am based in...
  15. Diesel Engines (Mondeo Mk3)
    Hi everybody this is my 1st post here...I tend to prefer reading posts than writing them lol. Anyhoo for the hell of it I bought a Mk3 mondeo 2.0 130ps with a suspected injector fault. When I went to collect the car I jumped if off my own car to give additional cranking speed and the Mondeo...
  16. Mechanical (Focus Mk1)
    Hi I have a 2003 Focus 1.8 TDCI and two of the injectors have failed,so I just went ahead and replaced them all . At this stage I am now trying to re-programme the 4 injectors . I have tried using an F-Super with Formidable and also an ELM327 with Forscan and each time I put in the injector...
  17. Diesel Engines (Mondeo Mk3)
    Hi. I'm not that new here but this is my first post as until now I've been reading a lot around here but still have some doubts. I have an 01/2003 2.0 TDCI Mondeo 130hp with 134k miles and I've been having P0251 issues but only when I'd try to move the car in 1st gear by releasing the clutch...
  18. Diesel Engines (Mondeo Mk3)
    Hi everyone, my friend is having serious problems with power output with his TDDi 90 which is ~115 000 miles on the clock. His problems were various, problem to start, no answer on throttle after start (rarely) and generally very low power. Diag shown no errors. I tried to live-diag it on run...
  19. Diesel Engines (Mondeo Mk3)
    Hi, I have a 2007 mondeo 2.0 tdci which has very recently developed a very slight misfire. Its hardly noticeable but seems to be getting gradually worse particularly when sitting at around 2000 revs. Also, when you accelerate quite a bit of smoke comes out the exhaust. Its not white smoke but...
  20. 1.6L to 2.0L Zetec Engines (Mk1/Mk2 Mondeo)
    Hi everyone! My first post so sorry if I'm in the wrong place. I had an idea, I've got a standart Ford Mondeo 2.0 Zetec with approx. 135 bhp. In an attempt to get more horses out of this engine "cheaply" I was thinking about putting on some Suzuki GSX 750 carbs! The real question is, what...
1-20 of 61 Results
Top