Ford Automobiles Forum banner
thermostat
1-20 of 24 Results
  1. 1.8L / 2.0L Duratec Petrol Engines (Mondeo Mk3)
    Hi all, does anyone know any suppliers of radiator hoses for the Mk3 2L petrol Duratec, other than Ford agents at ludicrous prices? I need to do the thermostat and clean the EGR valve on mine, which means hose removals - and with age of the car I suspect the hoses are getting a bit brittle or...
  2. Ford Ka Mk1 Forum (1996-2008)
    Hello people of this forum! I am new to this forum and i dont know alot about cars, yet. I've got this irritation of a problem with my ford ka champion from 2006. The Thermostat housing is broken i think. Because of this my car is loosing cooling fluid. I have cracked open the hood of my car...
  3. Diesel Engines (Mondeo Mk3)
    Hello Member of Talk Ford Please I need some help with my engine Mondeo MK3 TDDI 2L (300K ) with problem of Overheating on High speed or claiming Hills Symptoms : The engine over Heat on highway when I pass 120 Km/h or claiming Hill with speed More than 60Km/h There are no sign of...
  4. Ford S-Max Forum
    I am having a nightmare changing the thermostat on my 2.0 Diesel S-Max. I’ve finally managed to remove all 6 hoses and one of the electrical connectors from the housing and have freed it enough to almost remove, but I cannot get past the gear select rods that are stopping it coming off. Does...
  5. 1.8L / 2.0L Duratec Petrol Engines (Mondeo Mk3)
    I did a video on replacing the thermostat:
  6. Diesel Engines (Mondeo Mk3)
    Hi Guys, so I wanted to change my oil stat, but the process stopped when I want buy the new one(genuine ford). As I know well I should not able to blow air trough the thermostat without any resistance(on room temp). Or maybe I am wrong? The one what I tested a was a totally new one. Regards...
  7. Diesel Engines (Mondeo Mk3)
    Hi all - I have a new (to me) 2 Ltr 2004 Zetec TDCI Didn't notice on the test drive so bought it but coming home after the temp gauge took forever to eventually move to halfway. If I run the engine when stopped with the heater on, the heater gets warm(ish) but again the dash temp gauge dosnt...
  8. 1.8L / 2.0L Duratec Petrol Engines (Mondeo Mk3)
    Thermostat with or without actuator? Subject: Mondeo MK3 1.8 16V Duratec HE SFI (125 PS) / 147,000 km Prod. Date: 19-05-2006 Thermostat-housing has been recently replaced. Originally there was a thermostat no. 1476205 to seehttp://tinyurl.com/p8xyn5g, used on Mondeo from 10 nov 2005 to 19...
  9. Diesel Engines (Mondeo Mk3)
    Need some expert advice please... car is a 2006 TDCi 115PS manual, Euro IV (I think). I changed BOTH thermostats because I thought the car was running a bit too cool, so I assumed one of them was stuck open. The oil cooler stat I did while I was clearing out the inlet manifold and EGR (highly...
  10. Ford Fiesta Mk4 / Mk5 Forum - (1995-2002)
    Hi guys. Was wondering if anyone will be able to diagnose my problem?!? Ive recently purchased a 1.4L Fiesta 1998 and the cars temperature gauge seems to be all over the place. When idling the car is perfectly fine, between speeds of 0-50mph the car stays within the "normal" parameters on the...
  11. Mechanical (Focus Mk1)
    Hi again, I seem to have a problem with my focus and it's ability to retain water... I have narrowed down the offending area to the Thermostat housing, water seems to be pouring out from the bottom/under it. I have checked the pipes and all seem to be fitted properly, un-damaged and leak free...
  12. 1.8L / 2.0L Duratec Petrol Engines (Mondeo Mk3)
    Hi!! I hope that someone can help or advise me. My wife drives a 53 plate 1.8, and since a major service a few weeks ago she has said that the engine fan seems to be on high most of the while. The temperature gauge says normal, but when i go into dashboard diagnostics is says the the cylinder...
  13. Mechanical (Mk2 Focus)
    Hoping someone can help I have a 55 plate focus. 2.0 recently my temp gauge has starting dancing. I have no issue when I first set of but once the needle sits at half way (80/100) it starts to fall down to cold, the shoot back up half way then down to cold etc. I have encloced a video on...
  14. 1.8L / 2.0L Duratec Petrol Engines (Mondeo Mk3)
    Hi Can anybody help me with a cooling problem with my Mondeo MK3 2.0L 16v 2001. Since I got it the cooling fan has always cut in after about 30 seconds of starting the car and stayed on. Now the temp gauge is only going to 1/4 instead of the usual 1/2 reading? Do I need to change the temp...
  15. Air-Con / Heating (Mk4 Mondeo)
    My 1.8 tdci never seems to manage to hit 90 degrees. It is always 75/80 but sits there solid ass a rock with no fluctuation! Any idea if it should be hitting 90? Many thanks
  16. Mechanical (Mk2 Focus)
    Hi. Does anyone know where I can find a thread on how to change the thermostat/housing for a '07 Focus? I cant seem to find one. If there isn't one, could someone walk me through how to do it? Apparently its going to cost $700 for this job at a mechanic and I'd rather do it myself. Thanks in...
  17. 1.8L / 2.0L Duratec Petrol Engines (Mondeo Mk3)
    So I got a new thermostat due to my cars poor fuel economy, and also my temperature never getting above high 80s at a push. Today I went to do the swap, got the old one out, put it in my hand, the new one in my other hand, and..they are different. The original one from out of my car has no...
  18. 1.6L to 2.0L Zetec Engines (Mk1/Mk2 Mondeo)
    Last couple of days I've noticed my Mondeo's running a little hot. Tonight the temperature went right to the top of the 'Normal' range. Turning on the heater sorted that and when I parked up it was well in the normal range. I lifted the bonnet and heard a bit of a hiss of air escaping from the...
  19. Air-Con / Heating (Mk3 Mondeo)
    I wonder if anyone can help me on this one. I have a Mondeo 2.0 petrol Ghia '52. For a while now the heating takes a while to kick in (about 5 miles/10 minutes) and comes on rapidly, if the engine revs are greater than approximately 2,000rpm. However, when the engine is idling no heat comes...
  20. Diesel Engines (Mondeo Mk3)
    hello i am looking to buy a mk3 , 2003, 2.0 , tdci , black leather , clima , it looks OK but it has something strange with the temperature it reaches only aprox 40 degrees C , while driving in traffic for 30 min ?!?! also if i open the oil level or\and oil cap it has a sort of vapor or smoke...
1-20 of 24 Results
Top